Welcome to MotoMoz.com!
FAQFAQ   SearchSearch      ProfileProfile    Private MessagesPrivate Messages   Log inLog in

Suzuki DR250 stalls off idle

  
   Motorcycle Help Forums (Home) -> Tech RSS
Related Topics:
Suzuki GSX 250 1980 stalls and idle speed drops to zero - I am a newbie riding a Suzuki GSX 250 1980 and have been having problems with it stalling after a few kms of riding. It only seems to happen when its climbing. Slight backfire then a loss of power. If it's hot the oil light comes on and it won't start..

1975 Honda CB750K5 uneven idle, stalls below 1000 rpm - Hello again, This is the same bike as my previous question; it idles fairly steady at about 1500 rpm but won't go lower without chugging and after a few seconds it will stall if it gets under 1000 rpm. I've removed and cleaned the The..

[b]03 yamaha r6[/b] engine stalls - ridiing the rpms suddenly start to go way down like 500 and throttle responce is lacking. the needle floats between 0 and 500 rpms and then stalls. this also happens while i'm riding i'll notice the throttle response is not there. the..

Magna v30 stalls when fuel low - My Magna v30 runs perfecly when the fule in the tank is full. When it gets about half empty it will stall at idle. Like I said it will run at idle perfecly but at half tank will stall. I can't figure it out. The only thing I can think of is what I..

Idle will not go below 4000 RPM - Hi, I am trying to fix my Suzuki GS 450 LJ and ran into a problem that I can't seem to figure out. My idle won't go below 4000 RPM. I tried tweaking the RPM with the throtle stopper screw and the carbs, but I can only make it higher (I got to..
Next:  PI thanks  
Author Message
cramersec

External


Since: Jun 07, 2007
Posts: 5



(Msg. 1) Posted: Tue Oct 23, 2007 9:02 am
Post subject: Suzuki DR250 stalls off idle
Archived from groups: rec>motorcycles>tech (more info?)
I have a 1993 DR250. It seemed to not be accelerating well, so i
decided to pull the carb and clean it out. It actually looked pretty
clean, although when i put it back on the bike started much quicker
than usual, so I assumed i had fixed something. Rode it down the road
a couple of miles, and it started to bog. I stopped and it would idle
and re-start fine, but as soon as I cracked the throttle it would
stall. Limped it back home and took it to a local tech, who says he
has gone through the carb multiple times to no avail. Ideas?

Steve

 >> Stay informed about: Suzuki DR250 stalls off idle 
Back to top
Login to vote
Albrecht via MotorcycleKB

External


Since: Jun 07, 2007
Posts: 521



(Msg. 2) Posted: Tue Oct 23, 2007 4:34 pm
Post subject: Re: Suzuki DR250 stalls off idle [Login to view extended thread Info.]
Archived from groups: per prev. post (more info?)
cramersec wrote:
Ideas?

It's the same problem that I have talked about in this group a bazillion
times.

The idle mixture circuit is plugged up with gum and varnish.

The idle mixture screw is underneath the carburetor, downstream of the
throttle butterfly.

The idle mixture screw is hidden behind an aluminum plug that has to be
drilled out if you want to adjust the screw.

The idle mixture screw controls the single idle mixture port directly above
it.

If you don't want to bother with removing the carburetor and drilling out the
plug so you can do a proper job of cleaning out the port, at least pour about
three ounces of the non-aerosol Berryman B12 Choke and Carburetor Cleaner
into a full tank of gasoline and ride until the problem goes away.

If you want, you can use the aerosol B12 instead. Squirt it down the air jets
until it comes out the idle jets and the single idle port and the three idle
ports next to the throttle butterfly.

http://houseofmotorcycles.bikebandit.com/parts/Suzuki/DR250SEP/1993/994454

--
Message posted via MotorcycleKB.com
http://www.motorcyclekb.com/Uwe/Forums.aspx/tech/200710/1

 >> Stay informed about: Suzuki DR250 stalls off idle 
Back to top
Login to vote
cramersec

External


Since: Jun 07, 2007
Posts: 5



(Msg. 3) Posted: Wed Nov 07, 2007 12:44 pm
Post subject: Re: Suzuki DR250 stalls off idle [Login to view extended thread Info.]
Archived from groups: per prev. post (more info?)
On Oct 23, 11:34 am, "Albrecht via MotorcycleKB.com" <u33665@uwe>
wrote:
> cramersec wrote:
>
> Ideas?
>
> It's the same problem that I have talked about in this group a bazillion
> times.
> The idle mixture circuit is plugged up with gum and varnish.

Sorry I'm so long getting back to you on this. I don't understand your
suggestions. Maybe I wasn't clear, or just don't have the background,
but it idles fine. Isn't that what the idle circuit does?

> pour about
> three ounces of the non-aerosol Berryman B12 Choke and Carburetor Cleaner
> into a full tank of gasoline and ride until the problem goes away.

Again, perhaps I was not clear. I can't ride it. It will only idle.

Thanks again

Steve
 >> Stay informed about: Suzuki DR250 stalls off idle 
Back to top
Login to vote
jhunt1x1

External


Since: Dec 22, 2004
Posts: 214



(Msg. 4) Posted: Wed Nov 07, 2007 5:47 pm
Post subject: Re: Suzuki DR250 stalls off idle [Login to view extended thread Info.]
Archived from groups: per prev. post (more info?)
On Tue, 23 Oct 2007 09:02:35 -0700, cramersec <cramersec RemoveThis @gmail.com> wrote:

>I have a 1993 DR250. It seemed to not be accelerating well, so i
>decided to pull the carb and clean it out. It actually looked pretty
>clean, although when i put it back on the bike started much quicker
>than usual, so I assumed i had fixed something. Rode it down the road
>a couple of miles, and it started to bog. I stopped and it would idle
>and re-start fine, but as soon as I cracked the throttle it would
>stall. Limped it back home and took it to a local tech, who says he
>has gone through the carb multiple times to no avail. Ideas?

My '95 DR 250 is doing the same thing. I haven't dug into it yet but it's
almost certainly something blocking the main jet. It idles just fine and runs
up to about half throttle just like nothing is wrong, but when I give it full
throttle it just dies.

I haven't opened it up yet but I'm assuming there's an idle circuit, a
transition circuit, and a main circuit. In my case the main is plugged, and in
your case I'd suspect the transition circuit. This circuit is often a tiny slit
in the throttle bore next to the throttle plate. It would be easy for this slot
to get clogged and not be apparent. Take the carb back off and look for that
slot. Shoot it with compressed air and then see if aerosol carb cleaner will
shoot through it.

--
Jack Hunt IBA#12795, STOC 1870
'99 ST1100, FaST Forward
'95 Suzuki DR250SE
http://www.huntslodge.com
 >> Stay informed about: Suzuki DR250 stalls off idle 
Back to top
Login to vote
Display posts from previous:   
   Motorcycle Help Forums (Home) -> Tech All times are: Pacific Time (US & Canada) (change)
Page 1 of 1

 
 You can post new topics in this forum
You can reply to topics in this forum
You can edit your posts in this forum
You can delete your posts in this forum
You can vote in polls in this forum



[ Contact us | Terms of Service/Privacy Policy ]